Arriva London Engineering assists in trial to turn older diesel engine powered buses green.

  
  

Arriva London is always striving to improve its green credentials, with over 25% of its buses already hybrids and more to come, plus running the only all electric route in London on route 312, any new ideas and technology that can accelerate these green goals is always welcome.

A new idea to turn older diesel engine buses into much more environmentally friendly vehicles has been developed by Vantage Power Ltd based in Greenford, West London in association with Ensign Ltd, the largest reseller of buses in the UK.

The new unit will start trials in July, when two of Arriva London’s 2005, Volvo B7TL, Euro 3 buses, with Alexander Dennis bodies, VLA99 and VLA100 will resume service following their conversion. The trials are fully supported by TfL.

The basic idea behind the unit, is that the old diesel unit that currently drives the wheels is removed, and a retrofit diesel/electric hybrid is fitted. In the new unit, the smaller diesel engine charges the batteries and this power is then used to drive the wheels. Further efficiencies are realised by using the motor that drives the bus in normal operation, as a generator when the bus is slowing down, having the effect of putting more power back into the battery pack, enabling the diesel engine to stay off for longer.

The new system will be tested to see how well it performs against its targets of 40% reduction in the use of fuel, 80%+ reduction in emissions, and a cost saving for the unit which is estimated to be 80% less than a new Hybrid bus.

Jon Harman, Arriva London’s Chief Engineer said:

“London’s Ultra Low Emissions Zone (ULEZ) requires all double deck buses to be hybrid/electric by 2020, so the challenges of reducing emissions when running such a large fleet are significant.

What’s particularly exciting about this initiative is that Vantage Power have developed a retrofit hybrid pack that has the potential to extend the life of conventional diesel vehicles, that would otherwise become non-compliant.  The system they have developed is packed into a cradle and fits into the same space and fixes to the same mounting points as the outgoing powertrain, thus negating the need for any cutting, welding or relocating of components in the vehicle.

As well as testing of the hybrid retrofit system, the trial will also test another key feature of this system, which is geo-fence technology.  This technology, uses GPS information combined with route information, and can enable the vehicle to ensure its batteries are at full charge before entering certain areas (such as the ULEZ), or past schools, or libraries, and upon entering these areas, the engine can shut itself down and the vehicle then operate as an almost silent ZEV (Zero Emission Vehicle). Any new initiative which assists us in achieving this target is very welcome, and we look forward to being involved in this trial in a very practical way, by converting two of our buses and running them in service for the trial”.

  
  

Tags:   News
Published : Thu 14th Apr. 2016
Related archived articles
Published : Wed 18th Mar. 2015 - Thu 7th May. 2015
 
Back to school for an Arriva London Heritage Fleet bus

Arriva London were invited to The Crescent Primary School in Selhurst, a suburb of Croydon, to show some young school children what it’s like to ride on a big red double decker bus.

Cyclists Exchange places with Arriva London bus drivers

The Exchanging Places programme is an initiative between TfL and the Metropolitan Police, in which London’s cyclists are invited to experience what it is like to sit in the driver’s seat of a London bus or a large truck.

London emergency services accident simulation on the New Routemaster at Arriva London’s Clapton Garage
The idea of the exercise, which had been three months in the planning, was to give these services the opportunity to test out their recovery skills from a simulated accident of a New Routemaster.
Arriva London Night Controllers win the M.A.D 2014 Team of the Year award by making a difference

Every night in London, the Arriva London iBus control centres manage the efficiency of the Arriva routes throughout the city, and none more so than the Arriva London North Service Control team.e

Arriva London retains route 78

Arriva London has been successful in retaining route 78 (Shoreditch - Nunhead) at Ash Grove.

Arriva London Training Team drive to stardom with ITV’s Double Decker Driving School

When it comes to training bus drivers, the Arriva London Driving School is second to none, and as the new ITV six part series ‘Double Decker Driving School’ will show, learning to be a bus driver isn’t …

 

Please wait...

 

.Delivered by CSN MCL / All content copyright © 2007 - 2018 original copyright holders, except where individually stated. All rights reserved. E&OE.